【摘 要】
：
The solidification of Pb-16 %Sb hypereutectic alloy is investigated within ultrasonic field with a frequency of 15 kHz. It is found that the ultrasonic field pr
【机 构】
：
Department of Applied Physics
【基金项目】
：
西北工业大学校科研和教改项目;国家自然科学基金
论文部分内容阅读
The solidification of Pb-16 %Sb hypereutectic alloy is investigated within ultrasonic field with a frequency of 15 kHz. It is found that the ultrasonic field promotes crystal nucleation and terminates the further bulk undercooling of the alloy melt. Theoretical analysis shows that the cavitation effect and the forced bulk vibration are the main factors that reduce the undercooling level. With the increase of ultrasound intensity, the primary (Sb) phase experiences a growth mode transition from faceted to non-faceted branched growth, and the macrosegregation of primary (Sb) phase is gradually suppressed. In addition, the microstructures of Pb-Sb eutectic exhibit a conspicuous coarsening with increasing ultrasound intensity, and a structural transition of "lamellar eutectic-anomalous eutectic"occurs when ultrasound intensity rises up to 1.6 W/cm2. The ultrasonic field also changes the solute distribution adjacent to the solidification front, which lowers the Pb contents in primary (Sb) phase.
其他文献
Azeotropic liquid mixture cannot be separated by conventional distillation. But extractive distillation or combination of the two can be valid for them. An expe
A novel pressure and vacuum continuous control system, which adopts a hybrid pump as pressure and vacuum source, is presented. The mathematical model of the sys
In order to compensate for the limitation of conventional XY table used in semiconductor integrated circuits(IC) packaging and improve its speed and accuracy, a
为探究吕家坨井田地质构造格局,根据钻孔勘探资料,采用分形理论和趋势面分析方法,研究了井田7
Bax, a mammalian pro-apoptotic member of the Bcl-2 family, has been demonstrated to be a potential regulatory factor for plant secondary metabolite biosynthesis
A new type of transformation induced plasticity (TRIP) steel with not only high strength and high ductility but also superior welding and galvanizing properties
Refrigeration coefficient, ε, is usually calculatedby using the First Law of Thermodynamics. In this paper, anew derivation process is introduced through the c
In this paper, the authors obtain a necessary and sufficient condition for the Lp boundedness of commutators generated by Bochner-Riesz operators below a critic
Cadmium zinc telluride(CZT)is a preferred material for X-ray and gamma-ray detector.Thanks to the relatively high atomic number,high density and wide band-gap.C
There is an increasing demand for supporting high-quality real-time audiovisual services for the next generation wired and wireless networks. However, due to va