论文部分内容阅读
1.纸滤芯总成的除尘法队壳体内取出滤芯总成,放在平板上。首先用手轻轻拍震端面,去掉表面尘土及脏物,然后用毛刷顺皱纹方向轻轻刷去深处尘土,再用布头堵死端盖一端中心孔,由另一端用打气筒向里吹气,吹出含在滤纸微孔中的尘土。在除尘过程中,如果发现滤芯堵塞、滤纸表面损坏,端盖与滤纸压合粘接处开胶或尘污过多清洗不净时,必须更换。否则会影响柴油机正常工作。保养时,严禁用汽油、柴油,水清洗滤芯。其恶果是:用汽油清洗滤芯,由于滤纸微孔的吸湿性很强,会导致柴油机起动瞬间,滤芯微孔中所含汽油吸入气缸,产生迅速着火,容易造成飞车;用柴油清洗滤芯,由于滤纸吸湿的柴油不易挥发,柴油机工作中会使吸入的尘土大量粘附在滤纸表面及微孔中,降低透气性能,造成进气不足;用水清洗滤芯,由于滤纸表面和微孔中所含尘污,遇水会形成泥浆,糊死滤纸
1. The paper filter assembly dust removal France team shell filter assembly, on the flat. First gently pat the end face, remove the dust and dirt on the surface, and then use the brush along the direction of wrinkles gently brush to the depths of dust, and then plug the end cap end of the center hole, from the other end of the pump to blow Gas, blowing out the dust contained in the pores of the filter paper. In the process of dust removal, if the filter plug is found, the surface of the filter paper is damaged, the cover and the filter paper are pressed and glued to open the glue or the dust is too dirty to clean, it must be replaced. Otherwise it will affect the normal operation of diesel engine. Maintenance, non-use of gasoline, diesel, water filter cleaning. The consequences are: cleaning the filter with gasoline, the filter paper due to the hygroscopicity of micropores is very strong, will lead to the moment the diesel engine starts, the gas contained in the pores of the filter inhaled cylinder, resulting in rapid fire, easy to cause speed; diesel filter, Moisture absorption of diesel is not volatile, the diesel engine will work in a large number of dust inhaled in the filter paper surface and pores, reducing breathability, resulting in insufficient intake; water filter, the filter paper surface and the pores contained in the dirt, Water will form mud, plaster filter paper