造粒流化床反应器很早就被应用于水质软化过程。通过中试研究了造粒流化床反应器在不同pH值、晶种粒径、水力条件下处理效能和压力的变化。结果表明:针对当地水质,在反应器填充0.1~0.25 mm石榴石晶种、上升流速为60~100 m/h条件下,最佳投药量为110 mg/L,此时反应器出水pH值约为9.4,出水硬度为80 mg/L,去除率大于70%,碳酸氢盐为150 mg/L,出水浊度<1.0 NTU,对铁、锰的去除率分别约为40%和60%。结晶颗粒增长速率约为1.96×10-9m/s,排放粒径为0.9~1.2 mm,碳酸钙质量分数>99%。当水处理量为8 000 m3/d时,单位处理成本为0.65元/m3。这为实际工程建设提供了参考。 Pelletized fluidized bed reactors have long been used in water softening processes. Through the pilot study of the granulation fluidized bed reactor at different pH values, grain size, hydraulic conditions, treatment efficiency and pressure changes. The results showed that for the local water quality, when the reactor was filled with 0.1-0.25 mm garnet seeds and the rising flow rate was 60-100 m / h, the optimum dosage was 110 mg / L. At this time, the pH value of reactor effluent was about Was 9.4, the effluent hardness was 80 mg / L, the removal rate was more than 70%, the bicarbonate was 150 mg / L, the effluent turbidity was less than 1.0 NTU, and the removal rates of iron and manganese were about 40% and 60% respectively. The growth rate of crystalline particles is about 1.96 × 10-9m / s, the discharge particle size is 0.9 ~ 1.2mm, and the mass fraction of calcium carbonate is more than 99%. When the water treatment capacity is 8 000 m3 / d, the unit treatment cost is 0.65 yuan / m3. This provides a reference for the actual construction.